Complete workshop repair & service manual with electrical wiring diagrams for Freightliner Coronado (Coronado 122, Coronado SD122, Coronado 132) Trucks. It's the same service manual used by dealers that guaranteed to be fully functional and intact without any missing page.

This Freightliner Coronado (Coronado 122, Coronado SD122, Coronado 132) Trucks service & repair manual (including maintenance, overhaul, disassembling & assembling, adjustment, tune-up, operation, inspecting, diagnostic & troubleshooting…) is divided into different sections. Each section covers a specific component or system with detailed illustrations. A table of contents is placed at the beginning of each section. Pages are easily found by category, and each page is expandable for great detail. The printer-ready PDF documents work like a charm on all kinds of devices.

“STI-495, S2 (12_10P).pdf”
Freightliner Coronado Trucks Service Manual
Models: Coronado 122, Coronado SD122, Coronado 132
STI-495, S2 (12/10P); 1,416 pages

Service Manual Contents
Group No. Group Title
00 . . . . . . . . . . . General Information
01 . . . . . . . . . . Engine
09 . . . . . . . . Air Intake
13 . . . . . . . . . . . . . . . Air Compressor
20 . . . . . . . . Engine Cooling/Radiator
25 . . . . . . . . . . . Clutch
26 . . . . . . . . . . . . . . . . Transmission
30 . . . . . . . . . . . . . . . Throttle Control
32 . . . . . . . Suspension
33 . . . . . . . . Front Axle
35 . . . . . . . . Rear Axle
40 . . . . . . . . . . . . . Wheels and Tires
41 . . . . . . . . . Driveline
42 . . . . . . . . . . Brakes
46 . . . . . . . . . Steering
47 . . . . . . . . . . . . Fuel
49 . . . . . . . . . Exhaust
54 . . . . . . . . . . Electrical, Instruments, and Controls
60 . . . . . . . . . . . . Cab
72 . . . . . . . . . . . Doors
82 . . . Windshield Wipers and Washer
83 . . . . . . Heater and Air Conditioner
88 . . . Hood, Grille, and Cab Fenders
91 . . . . . Seats and Restraint Systems
98 . . . . . . . . . . . Paint

— — — — — — — — — — — — — — — — — — — — — — — — — — —

“STI-494-7 (6/14).pdf”
122Sd and Coronado 132 Maintenance Manual; 131 pages

EXCERPT:
49.01 Diesel Exhaust Fluid System, EPA10
Tank Removal and Installation
Installation
1. Install the tank into the mounting cage
2. Install the tank retaining bracket on the tank mounting cage studs. Install two nuts on the tank retaining bracket and tighten the nuts 12 lbf·ft (16 N·m).
3. Connect the vent line.
4. Remove any white DEF crystals from the DEF ports on the header unit and the DEF line couplings.
IMPORTANT: To connect a DEF line, push the line coupling onto the DEF port male connector, then pull back gently on the coupling to engage the holding clip in the locked position.
5. Connect the DEF supply and return lines to the tank header unit.
6. Connect the DEF line heater wiring harnesses to the DEF lines at the tank.
7. Connect the coolant lines to the tank header unit.
8. Connect the coolant valve and DEF level and temperature sensor wiring harnesses to the tank header unit.
9. Fill the DEF tank.
10. Install the beauty cover, if equipped.
11. Fill the cooling system and check for leaks. For instructions, see Group 20.
12. Close the hood.
…