Complete digital official shop manual contains service, maintenance, and troubleshooting information for the Volvo S60 2010-2016. Diagnostic and repair procedures are covered in great detail to repair, maintain, rebuild, refurbish or restore your vehicle like a professional mechanic in local service/repair workshop. This cost-effective quality manual is 100% complete and intact as should be without any missing pages. It is the same factory shop manual used by dealers that guaranteed to be fully functional to save your precious time.

This manual for Volvo S60 2010-2016 is divided into different sections. Each section covers a specific component or system and, in addition to the standard service procedures, includes disassembling, inspecting, and assembling instructions. A table of contents is placed at the beginning of each section. Pages are easily found by category, and each page is expandable for great detail. It is in the cross-platform PDF document format so that it works like a charm on all kinds of devices. You do not need to be skilled with a computer to use the manual.

EXCERPT:
Engine Intake And Exhaust System - Cleaning, Inspection And Adjustment
CRANKCASE VENTILATION (B5204T5; B5254T4; 2004-2007)
CRANKCASE VENTILATION, CHECK
Special tools:
9997226
Check
Measuring the pressure in the crankcase
NOTE: Take readings at idle at operating temperature.
Warm up the engine until the thermostat opens.
Switch of the AC and other electrical equipment.
Reset the manometer using the adjuster screw.
Remove the dip stick and connect manometer 9997226 as illustrated.
Reading off manometer value
NOTE: The pressure values are given for sea level. High levels can reduce the reading
slightly.
Read off manometer value.
The value for a clean crankcase ventilation is -0.2 kPa or lower.
If the manometer indicates a value from -0.2 up to 0.0 kPa or a positive value, the crankcase ventilation is partially or completely blocked and must be cleaned. Crankcase ventilation, cleaning
CLEANING THE CRANKCASE VENTILATION
Applies to S60/V70 (00-)/V70XC (01-)/S80
5-cyl turbo, see Crankcase ventilation, cleaning .
6-cyl turbo, see Cleaning the crankcase ventilation.
6-cyl non-turbo, see Cleaning the crankcase ventilation.
Cleaning the crankcase ventilation
Removing
Remove the screws, x 10, at the intake pipe mating flange.
Lift off the upper section of the intake pipe.
Install 9995723 .
Remove:
the dipstick tube
the thick hoses, 2 x, from the T nipple.
Cleaning
...